進口工程塑料隔膜泵|四氟乙烯隔膜泵(Imported plastic diaphragm | diaphragm tetrafluoroethylene)
產品概述(product description)
氣動隔膜泵是為目前國內穎的一種泵類，結構簡單、拆修方便、送液穩定、振動小、噪聲低、自吸能力強、輸送液體粘度高，具有自吸泵、潛水泵、屏蔽泵、泥漿泵和雜質泵等輸送機械的許多優點。采用壓縮空氣為動力源，對于各種腐蝕性液體，帶顆粒的液體，高粘度、易揮發、易燃、劇毒的液體，不易流動的液體均能予以抽光吸盡。已被國內數萬家石油、化工、食品、醫藥、電子、陶瓷、紡織、釀造、造紙系統單位采用，安置在各種特殊場合，用來抽送種常規泵不能抽吸的介質，均取得了滿意的效果。
隔膜是隔膜泵的核心部件，根據不同介質，可選用氯丁橡膠、四氟橡膠、丁晴橡膠等，以滿足不同用戶的要求。泵體過流部分，可根據用戶要求，選用鑄鐵、鋁合金、不銹鋼和工程塑料等不同材質。
Pneumatic diaphragm pump is currently the most innovative kind of pumps, simple structure, convenient overhaul, sending liquid stable, small vibration, low noise, self-absorption capacity, transmission fluid viscosity is high, with a self-priming pump, submersible pumps, shield pump, mud pump and impurity pump many advantages such as transportation machinery. Using compressed air as a power source for all kinds of corrosive liquid, with particles of high viscosity, volatile, flammable, poisonous liquid, easy-flowing liquid can be pumped optical exhaustion. The performance parameters and the Federal German WLLDENPVMPS, American MARIOWPUMPS similar. Has been adopted by tens of thousands of domestic petroleum, chemical, food, pharmaceutical, electronics, ceramics, textiles, brewing, paper system unit, housed in a variety of special occasions, for pumping kind of conventional pumps can not pump the media, have achieved satisfactory Effect.
The diaphragm is the core component of a diaphragm pump, according to the different media, the choice of chloroprene rubber, PTFE rubber, nitrile rubber, etc., to meet different user requirements. Pump flow part, according to user requirements, the choice of cast iron, aluminum, stainless steel and plastic of different materials.
產品特點(Features)
1、不需灌引水，吸程高達5米，揚程達70米，出口壓力≧7bar；
2、流動寬敞，通過性能好，允許通過顆粒直徑達10毫米。抽送泥漿、雜質時，對泵磨損甚微；
3、揚程、流量可通過氣閥開度實現無級調節(氣壓調節在1-7bar之間)；
4、該泵無旋轉部件，沒有軸封，隔膜等抽送的介質與泵的運動部件、工件介質*隔開，所輸送的介質不會向外泄漏。所以抽送有毒、易揮發或腐蝕性介質時，不會造成環境污染和危害人身安全；
5、不*電，在易燃、易爆場所使用安全可靠；
6、可以浸沒在介質中工作；
7、使用方便、工作可靠、開停只需簡單地打開和關閉氣體閥門，即使由于意外情況而長時間無介質運行或突然停機泵也不會因此而損壞，一旦超負荷，泵會自動地停機，具有自我保護性能，當負荷恢復正常后，又能自動啟動運行；
8、結構簡單、易損件少，該泵結構簡單，安裝、維修方便，泵輸送的介質不會接觸到配氣閥，聯桿等運動部件，不像其他類型的泵因轉子、活塞、齒輪、葉片等部件的磨損而使性能逐步下降；
9、可輸送較粘的液體(粘度在1萬厘泊以下)；
10、本泵無須用油潤滑，即使空轉，對泵也無任何影響，這是該泵一大特點。
1, no irrigation water, suction up to 5 m, lift up to 70 m, the outlet pressure ≧ 7bar;
2, flow spacious, good performance, allowing the maximum particle diameter of 10 mm. Pumping mud, when impurities, little wear and tear on the pump;
3, lift and flow can be adjusted by stepless valve opening degree (pressure adjustment between the 1-7bar);
4, the pump with no moving parts, no seals, diaphragm pumps and other pumping media with moving parts, completely separated from the workpiece medium, the transmission medium does not leak out. So pumping toxic, volatile or corrosive media, will not cause environmental pollution and danger to personal safety;
5, do not have electricity, safe and reliable in flammable and explosive places;
6, can be immersed in media work;
7, easy to use, reliable, open stop simply open and close the gas valve, even if because of accident-free medium long run or sudden stop pump will not be damaged, once the overload, the pump will automatically shut down with self-protection performance, when the load is normal, also can start automatically;
8, simple structure, less wearing parts, simple pump structure, installation, easy maintenance, pumping medium does not come into contact with the valve, linkage and other moving parts, unlike other types of pumps due to the rotor, piston, gear wear leaving the performance of the blade and other parts of the gradual decline;
9, can transport more viscous liquid (viscosity 10,000 cps or less);
10, this pump without oil lubrication, even idle, nor any effect on the pump, which is a major feature of the pump.
【訂貨須知】
一、若訂貨前還未選定型號，請向我們提供您的使用參數:①產品名稱與型號 ②流量 ③揚程（m） ④口徑 ⑤電機功率（KW） ⑥轉速（r/min） ⑦電壓〔V〕 ⑧吸程（m） ⑨是否帶附件以便我們的為您正確選型
二、若已經由設計單位選定我公司的產品型號，請按型號直接向我司銷售部訂購；
三、當使用的場合非常重要或管路比較復雜時，請您盡量提供設計圖紙和詳細參數，由我們美國歐可專家為您審核把關。
四、感謝您訪問我公司的網站/如有任何疑問.
您可以致電給我們-， 我們一定會盡心盡力為您提供優質的服務。
一、若訂貨前還未選定型號，請向我們提供您的使用參數:①產品名稱與型號 ②流量 ③揚程（m） ④口徑 ⑤電機功率（KW） ⑥轉速（r/min） ⑦電壓〔V〕 ⑧吸程（m） ⑨是否帶附件以便我們的為您正確選型
二、若已經由設計單位選定我公司的產品型號，請按型號直接向我司銷售部訂購；
三、當使用的場合非常重要或管路比較復雜時，請您盡量提供設計圖紙和詳細參數，由我們美國歐可專家為您審核把關。
四、感謝您訪問我公司的網站/如有任何疑問.
您可以致電給我們-， 我們一定會盡心盡力為您提供優質的服務。
